What flooring are you planning on putting down once the job's finished?
- Visitors can check out the Forum FAQ by clicking this link. You have to register before you can post: click the REGISTER link above to proceed. To start viewing messages, select the forum that you want to visit from the selection below. View our Forum Privacy Policy.
- Want to receive the latest contracting news and advice straight to your inbox? Sign up to the ContractorUK newsletter here. Every sign up will also be entered into a draw to WIN £100 Amazon vouchers!
Laying a smooth concrete floor
Collapse
X
-
-
I've laid a large concrete base before and had it floated (machine polished)
tbh if you want a perfectly level based I'd go with a lorry poured self levelling compound/screed, floating the floor gets it smooth but won't necessarily get it level.
with a self levelling compound you'd line the room with a damp proof membrane sheet and fill it to the desired level, a little bit of tamping here and there and voila! there really isn't that much to it.
https://www.youtube.com/watch?v=RZswb0_CNXY
http://www.flowscreedingservices.co.uk/installation/Last edited by Fandango; 28 August 2014, 13:45.Comment
-
Comment
-
As others have said, a self levelling screed should do the job quite easily, but you will need to hire a massive vibrator like these.Comment
-
Comment
-
Lay least favourite CUK posters on floor. Cover with concrete.
If MF there will be no flat finish.Comment
-
Originally posted by BrilloPad View PostLay least favourite CUK posters on floor. Cover with concrete.
If MF there will be no flat finish.Comment
-
concrete doesn't tend to leak unless its very wet or the shuttering is very poorly supported.
Lay dryish near the edge, build up slowly ish. support shuttering with bricks at right angles or concrete blocks.Comment
-
Opens Readers Digest DIY Manual for about the second time in the 20 years I've had it.
1 Make sure floor is not damp, if it's pre 1940 it may not have a damp proof membrane and damp will eventually ruin any surface you lay. If it is damp, remove any dust/dirt and repair any cracks with cement. Dry as much as possible with a fan heater and use 3 coats of moisture curing polyurethane sealant, allowing each to become touch dry before next. Scatter dry sand over the final coat before it dries.
2 If step 1 is not required, fill any significant indentations with sand and mortar mix. First brush with PVA adhesive and add a little to the mortar. When dry, clean floor with sugar soap and water. Rinse and allow to dry thoroughly.
3) Finish with a self levelling compound - very runny so levels itself. Follow mixing instructions on packet. Spread with a trowel to minimum depth of about 1cm or as needed to fill in any dips. It hardens very quickly, about 1 hour, but see instructions on packet before walking on it.bloggoth
If everything isn't black and white, I say, 'Why the hell not?'
John Wayne (My guru, not to be confused with my beloved prophet Jeremy Clarkson)Comment
-
Now I'm thinking if the floor needs concreting then I may as well first lay pipes for underfloor heating.
Even if these are capped off and not used for now, or ever by me, they might be a good selling point in future.
But presumably that means the concrete must be significantly deeper, and the pipes and labour of installing them would add a fair bit to the cost.
Does that sound like a good idea or is underfloor heating overrated and a bit of a gimmick?Work in the public sector? Read the IR35 FAQ hereComment
- Home
- News & Features
- First Timers
- IR35 / S660 / BN66
- Employee Benefit Trusts
- Agency Workers Regulations
- MSC Legislation
- Limited Companies
- Dividends
- Umbrella Company
- VAT / Flat Rate VAT
- Job News & Guides
- Money News & Guides
- Guide to Contracts
- Successful Contracting
- Contracting Overseas
- Contractor Calculators
- MVL
- Contractor Expenses
Advertisers
Contractor Services
CUK News
- What contractors can take from the Industria Umbrella Ltd case Yesterday 23:05
- Is ‘Open To Work’ on LinkedIn due an IR35 dropdown menu? Yesterday 05:57
- IR35: Control — updated for 2025-26 Sep 28 21:28
- Can a WhatsApp message really be a contract? Sep 25 20:17
- Can a WhatsApp message really be a contract? Sep 25 08:17
- ‘Subdued’ IT contractor jobs market took third tumble in a row in August Sep 25 08:07
- Are CVs medieval or just being misused? Sep 24 05:05
- Are CVs medieval or just being misused? Sep 23 21:05
- IR35: Mutuality Of Obligations — updated for 2025/26 Sep 23 05:22
- Only proactive IT contractors can survive recruitment firm closures Sep 22 07:32
Comment